Study of the Potential of Refuse Derived Fuel (RDF) at the Cipayung Final Disposal Site (TPA) to Meet Industrial Quality Standards and Environmentally Friendly

  • Gathut Imam Gunadi Universitas Pancasila
  • Taufik Nur Isman Mechanical Engineering Masters Study Program, Postgraduate Program, Pancasila University, Jakarta, Indonesia.
  • Ridwan Alawi Mechanical Engineering Masters Study Program, Postgraduate Program, Pancasila University, Jakarta, Indonesia.
  • Alvian Hadinata Tambunan Mechanical Engineering Masters Study Program, Postgraduate Program, Pancasila University, Jakarta, Indonesia.
  • Prawoto Mechanical Engineering Masters Study Program, Postgraduate Program, Pancasila University, Jakarta, Indonesia.
  • Eka Maulana Mechanical Engineering Masters Study Program, Postgraduate Program, Pancasila University, Jakarta, Indonesia.
Keywords: combustible waste, Waste to Energy, RDF (Refused-derived Fuel)

Abstract

The increased demand for energy is impacted by the growing population. As a result, new energy sources must be developed to replace the diminishing supplies. Waste to Energy (WTE) is a concept that can be used as an alternative to recycling waste into raw materials for Refuse Derived Fuel (RDF). Due to their combustibility, inorganic waste and plastic have the potential to be employed as source materials for RDF. In light of this discussion, RDF is required for both domestic and commercial purposes. chosen by classifying the garbage into different sizes and types. In order to demonstrate the huge potential for RDF treatment of active zone waste at the Cipayung Final Disposal Site (TPA), research has been conducted on the potential of RDF that meets industry standards and is environmentally friendly. From the analysis of available data, it is found that without using plastic and rubber waste, the calorific value of the RDF produced meets the required industry standards.

Downloads

Download data is not yet available.

References

Hadiwiyoto, S. (1983). “Handling and Utilization of Waste”. Idayu Foundation. Jakarta.

Damanhuri, E., and Padmi, T. (2010). Directorate of Waste Management. Bandung: ITB Environmental Engineering Study Program.

Izaty, Fatimah Nurul. 2018. "Analysis of Composition and Identification of Potential RDF (Refuse Derived Fuel) in Zone 1 Waste Piyungan Bantul with Proximate Analysis and Calorific Value.". Thesis. Indonesian Islamic University.

S. Raharjo, T. Matsumoto, T. Ihsan, I. Rachman, and L. Gustin, (2017) "Community-Based Waste Bank Program to Improve Municipal Waste Management in Indonesia: Case Study of Padang City," J. Mater. Cycle Waste Management, vol. 19, no. 1, p. 201–212.

Bimantara C. Ardi, (2012). “Potential Analysis of Refuse Derived Fuel (RDF) From Garbage Processing Units (UPS) in Depok City.” SINTEK JOURNAL, Vol. 13 No. 1, June 2019 p-ISSN: 2088-9038, e-ISSN: 2549-9645 59 (Case Study of UPS Grogol, UPS Permata Regency, UPS Cilangkap).

Rania, Mutiara Fadila, Lesmana. I Gede Eka., Maulana. Eka., (2019). "Analysis of Potential Refuse Derived Fuel (RDF) From Garbage at Final Disposal Sites (TPA) in Tegal Regency as Fuel for Pyrolysis Incinerators." SINTEK JOURNAL: Scientific Journal of Mechanical Engineering 13(1): 51–59.

Central Bureau of Statistics for City of Depok (2011). Depok in Numbers. From the Central Bureau of Statistics for the City of Depok.

Depok City Sanitation and Landscaping Service (2018). Depok City Garbage Piles Data 2018. Obtained from the Depok City Sanitation and Landscaping Service.

Sugiyono (2017). Quantitative Research Methods, Qualitative, and R&D. Bandung: Alfabeta.

Maulana. Eka., Suwandi. Agri., Rahmalina. Dwi., Firman. La Ode Mohammad., Suyitno, Budhi Mulyawan., Mahandika. Dhidik. (2021). “Analysis of Refuse Derived Fuel (RDF) Performance From Organic and Non-Organic Waste Using a Software Simulation Approach.” Technology Journal. Vol 13 no 1. Pages 109-114.

KK Ummatin and QAMO Arifianti, (2017) "Review and Analysis of Coal Substitution with Refuse Derived Fuel (RDF) in Cement Plants Using a Dynamic System," J. Eng. Sci app., vol. 91, p. 399–404.

Depok City Sanitation and Landscaping Service (2022). Depok City Garbage Piles Data 2022. Obtained from the Depok City Sanitation and Landscaping Service..

Dong, Trang T.T and Lee, Byeong-Kyu. (2009). “Analysis of potential RDF resources from solid waste and their energy values in the largest industrial city of korea.” Waste Management, 29, 1725-1731.

Indocement Tunggal Prakarsa, Tbk, Ltd (2012) “Utilization of RFD at PT Indocement Tunggal Prakarsa, Tbk.” Bogor.

Yuliarningsih, Rati (2019). “Utilization of Oil Sludge and Waste Biomass as Raw Materials for Densified Refuse Derived Fuels (D-RDF) for Alternative Fuels in the Cement Industry.” Masters Thesis, Andalas University.

Published
2023-02-10
How to Cite
[1]
G. Imam Gunadi, Taufik Nur Isman, Ridwan Alawi, A. H. Tambunan, Prawoto, and Eka Maulana, “Study of the Potential of Refuse Derived Fuel (RDF) at the Cipayung Final Disposal Site (TPA) to Meet Industrial Quality Standards and Environmentally Friendly”, JI, vol. 8, no. 1, pp. 73-81, Feb. 2023.